AWNING MAINTENANCE AND CARE

Maintaining a Carefree canopy is straightforward. simply follow these basic steps:

1. continuously operate the canopy per the directions.
2. sporadically make sure the fasteners ar tight. Tighten if necessary.
3 Keep the canopy cloth and arms clean.

FABRIC CARE

1. one in every of the simplest ways that to stay the material prosperous and to delay the requirement for deep or vigorous cleanings is to hose materials off on a monthly basis with clear water. This observe can facilitate forestall dirt from turning into deeply imbedded within the cloth. In most environments, an intensive cleanup are required each 2 to a few years.

2. once it’s time for an intensive cleanup, the material will be clean whereas still on the canopy frame.

1. For Vinyl cloth – Use a soft brush and heat water with soap.
2 For Acrylic cloth – Use a stiff brush and heat water with soap.

3. once cleanup the material, it's necessary to watch the following:

1. continuously use a natural soap, ne'er detergent.
2. Water ought to be cold to lukewarm, ne'er over 100F.
3. dry solely. ne'er apply heat to the material.
4. continuously enable the material to dry completely before rolling up the canopy.

Mildew

Mildew may be a plant life growth that appears like dirt. Vinyl coated polyester materials ar mildew resistant as a result of a chemical biocide within the vinyl coating. below standard conditions, mildew won't seem. However, in aras wherever warmth and wetness are common, mildew will be a retardant and needed the fabric to be washed additional oftentimes. completely rinse the material with clean water and permit to air dry utterly before rolling up the canopy.

Pooling

When water collects on the highest of the material, this is often referred to as "pooling". this may occur throughout inclement weather or if a running cooling system discharges over the canopy. The water is drop once the canopy is backward. it's suggested that if water accumulates on the top; retract the canopy in steps (8"-12") to dump the water. this can facilitate forestall the material from stretching or distorting.

The effects of wind Associate in Nursingd rain on an canopy ar unpredictable. Severe harm to the canopy and also the vehicle might result. IF WIND OR EXTENDED PERIODS OF RAIN ar EXPECTED, ROLL UP THE canopy AND SECURE FOR TRAVEL.

Leaking

For vinyl canopies, facet hems and poly cords of the canopy ar sewn in with a stitching machine. occasionally, this sewing might enable water to flow or leak through the stitches. this is often traditional and not a defect coated by warranted. Treat the seams with a high quality seam sealer.

ARM CARE

The best methodology of keeping the arms and braces in operation swimmingly is to wash them. Dirt and trash will cause the channels to not slide simply. sporadically wash out the channels with running water (i.e. a hose) to stay them clean. If the channels still don't slide simply, gently spray the joints and/or inside the channels with a dry siloxane lubricating substance when the arms are clean and dried completely.

Hardware Maintenance

1. Replace any components that become broken.
2. sporadically check all mounting hardware, screws, lags, etc., and re-tighten once necessary.
3. lockup knobs ought to be sporadically unsnarled and removed then sprayed with a dry lubricating substance to stop binding
and lockup.

MOTOR MAINTENANCE

1. Check all wiring and connections for wear. Repair once required.
2. make sure the sealing material is providing a decent seal and no water is accumulating on the wiring.